膜科学与技术

厌氧膜-生物反应器(AnMBR)处理高浓度豆制品废水的研究

作者：孙凯，陆晓峰，周保昌，卞晓锴

单位：中国科学院上海应用物理研究所

关键词：厌氧膜生物反应器; 豆制品废水; 水力停留时间; 膜污染

出版年,卷(期):页码： 2011,31(4):65-69

摘要：

采用膨胀污泥床反应器与外置管式超滤膜组成厌氧膜-生物(AnMBR)反应器处理高浓度豆制品废水,实验连续运行240d, AnMBR平均处理量30~160L/d,研究了反应器的处理效果并获得了最佳水力停留时间(HRT),实验结果表明:AnMBR反应器处理高浓度豆制品废水能够达到较好的效果,当进水COD为10 g/L左右时,最佳HRT为18h,COD去除率约90%,此时相对应的有机负荷(OLR)为13.6 kg COD /(m3•d);稳定运行期间,气体产率为0.10~0.25 L/g COD,甲烷含量在70%左右:在0.1MPa操作压力条件下进行膜的运行试验,考察了不同清洗方式的效果,采用最佳清洗方式膜通量可以恢复到新膜的90%左右.

The efficiencies of treating high-concentration soybean processing wastewater (30~160L/d) by a side-stream anaerobic membrane bioreactor (AnMBR) were studied for over 240 days. AnMBR was comprised of a expanded granular sludge bed reactor and a side-stream hyperfiltration membrane module.The effects of hydraulic retention time (HRT) on the system performance and efficiencies of different cleaning methods on the membrane fouling were explored. The optimal HRT was found to be about 18 h at 10 g COD/L feeding (OLR was about 13.6 kg COD /(m3•d)). During stable operational periods, approximate 70% methane was found in the biogas with an overall gas yield of 0.10~0.25 L/g COD. The operating conditions of membrane module with 0.1MPa operating pressure and the cleaning efficiencies of membrane fouling were studied. However, for different membrane cleaning methods, the study showed it could acquire approximate 90 percents flux recovery at the best condition.

孙凯(1983- ), 男, 湖北人, 硕士研究生,主要研究方向为厌氧膜生物反应器和水污染控制; 联系电话：021-39194512; E-mail:appolosun@126.com.* 联系作者：陆晓峰, 研究员, 联系电话：021-59555119; E-mail: xflu@sinap.ac.cn.

参考文献：

[1] Stephenson T, Judd S. 膜生物反应器污水处理技术[M]. 张树国,李咏梅,译. 北京:化学工业出版社,2003.
[2] Water Environmental Research Foundation (WERF). Membrane bioreactors for anaerobic treatment of wastewaters [EB/OL]. http://www.werf.org. 2007.
[3] 张欣欣,沈菊李,朱宝库,等,厌氧膜-生物反应器的研究及其在废水处理中的应用[J]. 膜科学与技术,2008,28(2):79-84
[4] 何义亮,吴志超,李春杰,等,厌氧膜生物反应器处理高浓度食品废水的应用[J]. 环境科学, 1999,20(6):53-55
[5] Biing-Teo Wong, Kuan-Yeow Show, Ay Su, et al. Effect of Volatile Fatty Acid Composition on Upflow Anaerobic Sludge Blanket (UASB) Performance [J]. Energy & Fuels,2008,22, 108-112.
[6] Fakhru'l-Razi, A., M. J. M. M. Noor. Treatment of palm oil mill effluent (POME) with the Membrane Anaerobic System (MAS)[J]. Water Science and Technology,1999,39(10-11):159-163.
[7] 康华,何文杰,王胜江,等,PVDF膜污染及清洗试验研究[J]. 给水排水,2008,34 (14):12-16.

服务与反馈：

【文章下载】【加入收藏】

《膜科学与技术》编辑部地址：北京市朝阳区北三环东路19号蓝星大厦邮政编码：100029 电话：010-64426130/64433466 传真：010-80485372邮箱：mkxyjs@163.com