膜科学与技术

PVDF及其共聚物膜的耐碱性能研究

作者：叶灿，周玥，刘飞，汪效祖，汪朝晖，崔朝亮

单位：南京工业大学化工学院材料化学工程国家重点实验室，南京 211816

关键词： PVDF；PVDF-HFP；PVDF-CTFE；耐碱性

出版年,卷(期):页码： 2022,42(1):72-79

摘要：

本文以聚偏氟乙烯（PVDF）、聚偏氟乙烯-六氟丙烯（PVDF-HFP）和聚偏氟乙烯-三氟氯乙烯（PVDF-CTFE）为膜材料，采用非溶剂诱导相分离法（NIPS）制备超滤、微滤膜。聚合物含量为20 wt%，添加剂含量为6 wt %，溶剂DMAc含量为74 wt%。使用场发射扫描电子显微镜（FESEM）、傅里叶红外光谱仪（FTIR）等仪器对制备的三种膜进行表征。碱性环境采用浓度为0.01、0.1、1、3和5 mol/L的氢氧化钠溶液构建，考察三种聚合物膜分别浸泡50 h后的耐碱性能。5 mol/L NaOH溶液浸泡50 h后，PVDF膜、PVDF-HFP膜以及PVDF-CTFE膜的断裂伸长率分别下降了95.3%，30.7%和22.6%；PVDF膜和PVDF-HFP膜的强度分别下降了34.5%和11.5%，PVDF-CTFE膜的强度没有明显降低。结果表明，同等级碱性环境中，两种共聚物膜的机械性能均优于PVDF膜，可塑性更好。拉曼测试结果表明，聚合物脱氟化氢形成碳碳双键，且脱氟化氢导致膜颜色变深，膜在碱液中发生降解，但两种共聚物膜的降解程度远低于均聚物膜。

In this paper, polyvinylidene fluoride (PVDF), polyvinylidene fluoride-hexafluoropropene (PVDF-HFP) and polyvinylidene fluoride-trifluoroethylene chloride (PVDF-CTFE) were used as membrane materials to prepare ultrafiltration and microfiltration membranes by Non-solvent induced phase separation (NIPS) method. The formula contains 20 wt% polymer, 6 wt% additive and 74 wt% solvent DMAC. Field emission scanning electron microscopy (FESEM), Fourier infrared spectroscopy (FTIR) and whiteness meter were used to characterize the three kinds of films prepared. Concentrations of 0.01, 0.1, 1, 3 and 5 mol/L sodium hydroxide solution was used to construct the alkaline environment. The alkali resistance of the three polymer membranes was investigated after immersion for 50 h. After soaking in 5 mol/L NaOH solution for 50 h, the elongation at break of PVDF, PVDF-HFP and PVDF-CTFE films respectively decreased by 95.3%, 30.7% and 22.6%. The strength of PVDF membrane and PVDF-HFP membrane respectively decreased by 34.5% and 11.5%, while PVDF-CTFE membrane did not decrease significantly. The results show that the mechanical properties and plasticity of the two copolymer membranes were better than that of PVDF membranes in the same alkaline environment. The results of Raman test show that the polymer defluorinated hydrogen formed carbon-carbon double bond, the defluorinated hydrogen resulted in the darkening of the film color and the degradation of the film in alkali solution, but the degradation degree of the two copolymer films was much lower than homopolymer films.

叶灿（1994,，10），硕士，江苏泰州，主要研究方向为膜分离

参考文献：

[1] Souzy R, Ameduri B, Boutevin B, et al. Functional fluoropolymers for fuel cell membranes [J]. Solid State Ion, 2005, 176(39-40): 2839-2848.
[2] Pezeshk N, Rana D, Narbaitz R M, et al. Novel modified PVDF ultrafiltration flat-sheet membranes [J]. J. Membr. Sci, 2012, 389:280-286.
[3] Ameduri B. From vinylidene fluoride (VDF) to the applications of VDF-containing polymers and copolymers: recent developments and future trends [J]. Chem. Rev, 2009, 109(12): 6632-6686.
[4] 杨庆. PVDF超滤膜低温等离子体改性及其在MBR中的耐污染性能研究 [D]. 兰州交通大学, 2015.
[5] Wang Z, Ma J, Tang C Y, et al. Membrane cleaning in membrane bioreactors: a review [J]. J. Membr. Sci, 2014, 468:276-307.
[6] 韩永萍, 肖燕, 宋蕾, 等. MBR膜污染的形成及其影响因素研究进展 [J]. 膜科学与技术, 2013, 33(1): 102-110.
[7] 郝艳霞, 李健生, 王连军. 固态粒子烧结法制备YSZ超滤膜 [J]. 中国陶瓷工业, 2005, 12(01): 22-25.
[8] 赵晓勇, 曾一鸣, 施艳荞, 等. 相转化法制备超滤和微滤膜的孔结构控制 [J]. 功能高分子学报, 2002, 15(04): 487-495.
[9] 邵斐斐. 熔融-拉伸法制备聚乙烯中空纤维膜 [D]. 天津工业大学, 2010.
[10] 张玉红, 吴鸣, 熊国兴, 等. 溶胶-凝胶法制备TiO2复合陶瓷光催化膜——制备前驱物对膜性质的影响 [J]. 功能材料, 2000, (05): 536-538.
[11] 邢丹敏, 武冠英, 胡家俊. 改性聚氯乙烯超滤膜的研究(Ⅰ)——等离子体改性膜结构和性能的研究 [J]. 膜科学与技术, 1996, (01): 49-55.
[12] Karkhanechi H, Vaselbehagh M, Jeon S, et al. Preparation and characterization of polyvinylidenedifluoride-co-chlorotrifluoroethylene hollow fiber membranes with high alkaline resistance [J]. Polymer, 2018, 145:310-323.
[13] Hashim N A, Liu Y, Li K. Stability of PVDF hollow fibre membranes in sodium hydroxide aqueous solution [J]. Chem. Eng. Sci, 2011, 66(8): 1565-1575.
[14] Luo S, Gao W, Shen J, et al. Influence of alkali treatment on the structure and dielectric properties of polyvinylidene fluoride [J]. Polym. Mater. Sci. Eng, 2020, 36(5): 42-48.
[15] Rabuni M F, Sulaiman N M N, Aroua M K, et al. Effects of alkaline environments at mild conditions on the stability of PVDF membrane: an experimental study [J]. Ind. Eng. Chem. Res, 2013, 52(45): 15874-15882.
[16] 刘璟言, 卢小艳, 朱燕茹, 等. 酸碱及氧化剂对聚偏氟乙烯超滤膜老化的影响[J]. 哈尔滨工业大学学报,2017,49(08):25-30.
[17] 沈菊李, 郑宏林, 潘窔伊, 等. PVDF中空纤维超滤膜的耐化学性能研究 [J]. 水处理技术, 2015, (8): 44-47.
[18] Ross G J, Watts J F, Hill M P, et al. Surface modification of poly(vinylidene fluoride) by alkaline treatment 1. The degradation mechanism [J]. Polymer, 2000, 41(5): 1685-1696.
[19] Zhang Y, Wang J, Gao F, et al. A comparison study: The different impacts of sodium hypochlorite on PVDF and PSF ultrafiltration (UF) membranes [J]. Water Res, 2017, 109:227-236.

服务与反馈：

【文章下载】【加入收藏】

《膜科学与技术》编辑部地址：北京市朝阳区北三环东路19号蓝星大厦邮政编码：100029 电话：010-64426130/64433466 传真：010-80485372邮箱：mkxyjs@163.com